Dietary effects of protected fat, glycerol, and soybean meal on performance, physiological parameters, carcass characteristics, and behavioral measurements of late-fattening Hanwoo steers under heat stress conditions.

Objective: This study aimed to determine the effects of increasing energy and protein levels in diets by including protected fat (PF), glycerol (GL), and soybean meal (SBM) on growth performance, physiological parameters, carcass characteristics, and behavioral measurements of late-fattening Hanwoo steers under heat stress conditions. Methods: Thirty-six steers (initial BW, 724.9 ± 58.3 kg; age, 25.5 ± 0.4 month) were assigned into Control (TDN 76%, CP 15%), PF (TDN 83.6%, CP 15%), PF+GL (TDN 83.6%, CP 15%) and PF+GL+SBM (TDN 83.6%, CP 16.5%) by randomized complete block design for a total of 16 weeks with division of 4 week periods. The average temperature-humidity index was 87.0 (1st period; Severe), 82.8 (2nd; Moderate), 71.4 (3rd; Comfort), and 68.1 (4th; Comfort). Results: The DMI showed no treatments differences during the whole experiment. However, DMI in 1st and 2nd period decreased by approximately 30% and 10% compared to 4th period, respectively. Higher ADG and FCR were noted for treatments compared to Control at both 1st and 2nd period (p<0.05). There were no treatment effects on rectal temperature (RT), cortisol, and behaviors during the entire experiment. However, both RT and cortisol in 0, 1st and 2nd period were higher than those of 3rd and 4th period (p<0.05). Carcass yield and grade remained unaffected by increasing TDN and CP levels. Behavioral changes in the hot season (1st period) included reduced lying (43%), increased standing (48%), decreased walking (62%), and decreased eating (38%) (p<0.05), with an increase in drinking by 54%. Rumination during standing was 53% higher, while rumination during lying was about 33% lower compared to the post-hot season (3rd period) (p<0.05). Conclusion: Dietary supplementation of protected fat in late-fattening Hanwoo steers under heat stress had a positive effect on preventing a reduction in performance.

A transcriptomic analysis of skeletal muscle tissues reveals promising candidate genes and pathways accountable for different daily weight gain in Hanwoo cattle.

Cattle traits like average daily weight gain (ADG) greatly impact profitability. Selecting based on ADG considering genetic variability can lead to economic and genetic advancements in cattle breeding. This study aimed to unravel genetic influences on ADG variation in Hanwoo cattle at the skeletal muscle transcriptomic level. RNA sequencing was conducted on longissimus dorsi (LD), semimembranosus (SB), and psoas major (PM) muscles of 14 steers assigned to same feed, grouped by low (≤ 0.71 kg) and high (≥ 0.77 kg) ADG. At P ≤ 0.05 and log2fold > 1.5, the distinct pattern of gene expression was identified with 184, 172, and 210 differentially expressed genes in LD, SB, and PM muscles, respectively. Tissue-specific responses to ADG variation were evident, with myogenesis and differentiation associated JAK-STAT signaling pathway and prolactin signaling pathways enriched in LD and SB muscles, while adipogenesis-related PPAR signaling pathways were enriched in PM muscle. Key hub genes (AXIN2, CDKN1A, MYC, PTGS2, FZD5, SPP1) were upregulated and functionally significant in muscle growth and differentiation. Notably, DPP6, CDKN1A, and FZD5 emerged as possible candidate genes linked to ADG variation. These findings enhance our understanding of genetic factors behind ADG variation in Hanwoo cattle, illuminating skeletal muscle mechanisms influencing ADG.

Effects of mid-to-late prepartum feed supplementation in Hanwoo beef cows on their performance, blood metabolites, and the carcass characteristics and metabolites of their neonatal calves.

Introduction: This study aimed to evaluate the implications of supplementary nutrition during the mid-to-late pregnancy on various parameters in Hanwoo cows and their subsequent neonatal calves. Materials and methods: Eight Hanwoo cows in their first parity were divided into two groups. The control group (C, 100%) received 3kg of concentrate and 5kg of rice straw throughout the pregnancy period, while the treatment group (T, 150%) increased their diet during mid-to-late pregnancy. Both performance assessments and blood metabolite analyses were performed for the pregnant cows. Neonatal calves were subjected to morphometric evaluations, blood sampling, and detailed morphometric analyses of carcasses and gastrointestinal components. Results: Performance indices of the cows showed that both Pregnancy Period (PregP) and Body Condition Score (BCS) were significantly improved with supplemental feeding (p <0.05). Improvements in Body Weight (BW) and Feed Conversion Ratio (FCR) were not statistically significant. Blood metabolite analysis for the cows revealed decreased levels of triglycerides (TGLate), non-esterified fatty acids (NEFALate), and progesterone (P4Late), with a notable increase in glucose (GluLate) levels (p <0.01). In the neonatal calves, anatomical metrics of the gastrointestinal tissues showed increased Omasum Width (OmasWdth) values in the supplemented group (p =0.053). There was significant increase of papillae and villus lengths in the rumen and small intestine (p <0.01 and p <0.05, respectively). Morphometric evaluations displayed longer body lengths (BLnth) and larger chest width (ChestWdth) in the treated calves (p <0.05 and p <0.01, respectively). Carcass characteristics showed no substantial variations between the groups, while blood analysis in the calves revealed decreased GPT levels in the nutritionally supplemented group (p<0.05). Discussion: The findings indicate that supplementing the diets of Hanwoo cows during mid-to-late pregnancy leads to significant changes in select maternal blood metabolites and influences specific anatomical and morphometric features in neonatal calves, all without significant shifts in carcass attributes.

Intramuscular fat formation in fetuses and the effect of increased protein intake during pregnancy in Hanwoo cattle.

Understanding adipocyte development in fetus during bovine pregnancy is important for strengthening fattening technology. Additionally, nutritional level of dams during pregnancy has the potential to improve offspring growth and fat development. The purpose of this study is to evaluate the intramuscular adipocyte development and expression level of related genes in bovine fetus, and the effect of increased crude protein (CP) intake during pregnancy on the growth performance and carcass characteristics of male offspring. Eighty six pregnant Hanwoo cows (average body weight, 551.5 ± 51.3 kg, age 5.29 ± 0.61 y) were used. Fetuses were collected at 90, 180 and 270 d of gestation from 18 pregnant Hanwoo cows. The remaining 68 pregnant cows were randomly assigned to 2 feeding groups. The control (CON) group was provided the standard protein diet (n = 34), and treatment (TRT) group was provided a diet with a 5% increase in CP intake (n = 34). Male offspring were divided into two groups according to protein treatment of the pregnant cows: CON male offspring (CON-O) and TRT male offspring (TRT-O). Intramuscular adipocytes were found in the fetal skeletal muscle after 180 days of gestation. Male calf's birth weight increased in the TRT group compared to that in the CON group (p < 0.002). The final body weight (p < 0.003) and average daily gain (p < 0.019) of male offspring were significantly higher in TRT-O than in CON-O. The feed conversion ratio was also improved by 10.5% in TRT-O compared to that in CON-O (p < 0.026). Carcass weight was significantly higher in the TRT-O group than that in the CON-O group (p < 0.003), and back fat was thicker in the TRT-O group (p = 0.07). The gross receipts and net income were higher in TRT-O than in CON-O (p < 0.04). Thus, fetal intramuscular fat can be formed from the mid-gestation period, and increased CP intake during pregnancy can increase net income by improving the growth and carcass weight of male offspring rather than intramuscular fat.

Identification of potential biomarkers associated with meat tenderness in Hanwoo (Korean cattle): An expression quantitative trait loci analysis.

Meat tenderness is considered the most important trait contributing to beef quality, level of consumer satisfaction, willingness to pay premium prices and industry profit. Genomic selection method would be helpful for genetic improvement of traits with low heritability and that are difficult to measure. The identification of core genes can aid genomic selection for complex traits with low heritability that are difficult to measure. We performed statistical analysis of associations between longissimus dorsi muscle tenderness and gene expression in 20 Hanwoo cattle, using Warner-Bratzler shear force and RNAseq data, respectively. We found a total of 166 core genes, from which six (ASAP1, CAPN5, ELN, SUMF2, TTC8 and MGAT4A) were regulated by 16 cis-expression quantitative trait loci (eQTL) SNPs. Notably, we found that a cis-eQTL SNP of the ELN gene contained an MFZ-1 binding site in its putative promoter region. These findings provide useful information for genomic prediction of beef tenderness in Hanwoo cattle.

Bovine Viral Diarrhea Virus Antibody Level Variation in Newborn Calves after Vaccination of Late-Gestational Cows.

This study was conducted to confirm variation in bovine viral diarrhea virus (BVDV) antibody levels transferred to calves from their mother's colostrum after vaccination of late-gestational cows. Blood samples were drawn from 60 pregnant cows that had been vaccinated more than one year and less than two years previously. The samples were collected six weeks prior to the expected date of delivery. After sample collection, the cows were divided into two groups of 30. One group received 2 mL of BVDV vaccine, and a control group received 2 mL of phosphate-buffered saline (PBS). Blood was collected from the cows three weeks post-administration. Additional blood samples were taken from calves at 1, 4, 8, 12, 16, and 20 weeks after birth. The serum was separated from the collected blood, and BVDV antibody changes were confirmed by enzyme-linked immunosorbent assays. BVDV antibody levels were higher from 8 to 20 weeks of age in calves born to late-gestational BVDV-vaccinated cows than in calves born to control cows (p < 0.0083). Further analysis confirmed a slow decline in BVDV maternal antibodies in calves born to pregnant cows that produced high levels of BVDV antibodies following pre-calving BVDV vaccination. These results suggest that BVDV vaccination of cattle in late pregnancy may help to extend the duration of protection against BVDV infection in newborn calves.

Effect of short-term fattening period and castration method on productivity, serum testosterone, and economic efficacy in Hanwoo cattle.

The purpose of this study was to evaluate the effects of castration method and short-term fattening periods on Hanwoo cattle. Thirty-two Hanwoo calves (average body weight: 148.4 ± 19.8 kg) were used. The calves were randomly assigned in a 2 × 2 factor according to two castration methods (castration or hemi-castration) and two short-term finishing periods (24 months or 26 months). The final body weight increased significantly as the fattening period increased (p < 0.05), and the average daily weight gain was higher in the hemi-castration groups than in the castration groups (p < 0.05). After surgical castration, testosterone concentration was higher in the hemi-castration group than in the castration group during the entire experimental period (p < 0.05). The rib eye area was wider in the hemi-castration group than in the castration group (p < 0.01).An interaction effect was observed between the castration method and short-term fattening period (p < 0.05). Marbling and auction price scores differed between castration methods and were higher in the castration group than in the hemi-castration group (p < 0.01). Gross receipts and net income increased in the castration group compared to the hemi-castration group (p < 0.01) and showed a tendency to increase with the short-term fattening period, but there was no significant difference. Thus, castration to remove both testicles is essential for economic profit through producing high-quality Korean beef meat, and short-term fattening for 26 months, rather than 24 months, can benefit more by increasing carcass weight and meat quality.

Prediction of total digestible nutrient and crude protein requirements according to daily weight gain, and behavioral measurements of Hanwoo heifers.

OBJECTIVE: This study was conducted to investigate the effects of energy and protein levels in the diet of Hanwoo heifers on growth response and animal behavior. METHODS: Forty heifers were randomly allocated into three experimental groups according to the target daily weight gain in 8 pens (T-0.2, 2 replications; T-0.4 and -0.6, 3 replications) based on similar body weight (BW) and age in months. The target average daily gain (ADG) was set at 0.2 (T-0.2), 0.4 (T-0.4), and 0.6 kg/d (T-0.6), and feed was based on National Institute of Animal Science (NIAS, 2017). In order to minimize hunger stress of T-0.2 and -0.4, the feeding ratio of rice straw was set to 55%, 50%, and 45% for T-0.2, -0.4 and T-0.6, respectively, so that the dry matter (DM) intake for all treatment groups was uniform but the energy and protein levels in the diet were adjusted differently. A total of 6 items (lying, standing, eating, rumination, walking and drinking) of animal behavior were analyzed. RESULTS: During the whole period of the experiment, the ADG of the T-0.2, -0.4 and -0.6 treatments were 0.48, 0.56, and 0.65 kg/d (p<0.05), respectively, showing higher gain than the predicted value, especially for the low target ADG group. Based on these results, regression equations for the total digestible nutrient (TDN) and crude protein (CP) requirements were derived. No behavioral differences were found according to the energy and protein levels in the diet because the DM intake was kept constant by adjusting the roughage and concentration ratio. However, eating time was longer (p<0.05) at T-0.2 than T-0.6 during the whole day. CONCLUSION: Through this study, it was possible to derive regression equations for predicting TDN and CP requirements according to the target ADG and BW.

Effects of feeding high-energy diet on growth performance, blood parameters, and carcass traits in Hanwoo steers.

OBJECTIVE: Our study aimed to investigate the effects of a 2% increase in dietary total digestible nutrients (TDN) value during the growing (7 to 12 mo of age) and fattening (13 to 30 mo of age) period of Hanwoo steers. METHODS: Two hundred and twenty Hanwoo steers were assigned to one of two treatments: i) a control group (basal TDN, BTDN, n = 111 steers, growing = 70.5%, early fattening = 71.0%, late fattening = 74.0%) or high TDN (HTDN, n = 109 steers, growing = 72.6%, early = 73.1%, late = 76.2%). Growth performance, carcass traits, blood parameters, and gene expression of longissimus dorsi (LD) (7, 18, and 30 mo) were quantified. RESULTS: Steers on the BTDN diets had increased (p≤0.02) DMI throughout the feeding trial compared to HTDN, but gain did not differ appreciably. A greater proportion of cattle in HTDN received Korean quality grade 1 (82%) or greater compared to BTDN (77%), while HTDN had a greater yield grade (29%) than BTDN (20%). Redness (a*) of LD muscle was improved (p = 0.021) in steers fed HTDN. Feeding the HTDN diet did not alter blood parameters. Steers fed HTDN diet increased (p = 0.015) the proportion of stearic acid and tended to alter linoleic acid. Overall, saturated, unsaturated, monounsaturated, and polyunsaturated fatty acids of LD muscle were not impacted by the HTDN treatment. A treatment by age interaction was noted for mRNA expression of myosin heavy chain (MHC) IIA, IIX, and stearoyl CoA desaturase (SCD) (p≤0.026). No treatment effect was detected on gene expression from LD muscle biopsies at 7, 18, and 30 mo of age; however, an age effect was detected for all variables measured (p≤0.001). CONCLUSION: Our results indicated that feeding HTDN diet could improve overall quality grade while minimum effects were noted in gene expression, blood parameters, and growing performance. Cattle performance prediction in the feedlot is a critical decisionmaking tool for optimal planning of cattle fattening and these data provide both benchmark physiological parameters and growth performance measures for Hanwoo cattle feeding enterprises.

Half-castration is a newly effective method for increasing yield and tenderness of male cattle meat.

OBJECTIVE: For improving meat quality especially tenderness, male cattle are usually castrated to removes both the testicles. This study was conducted to evaluate the effect castration method (half- and complete-castration) on meat yield and quality characteristics of Hanwoo male cattle. METHODS: Thirty-two similar age (5.9 months) Hanwoo male calves were divided into: half-castration (HC) and complete-castration (CC) groups (n = 16 per group). At 7 months of age, all the animals were castrated in which the HC calves had only one testicle surgically removed while, the CC calves had both testicles surgically removed. The castrated animals were reared under identical conditions until 25 months of age. After slaughter, the carcasses were evaluated for carcass traits and meat yield of primal cuts. For examination of the castration effect on meat quality, L. lumborum and semimembranosus muscles were used. The meat samples were analyzed for chemical composition, color, pH, shear force and water holding capacity, fatty acids, metabolites and volatile aroma compounds. RESULTS: The HC group showed higher meat yields of all primal cuts (p<0.05). As a result, the total meat yield was higher by approximately 44 kg in the HC group (303.32 kg, corresponding to 67.88%) compared to the CC group (259.30 kg, corresponding to 62.11%) (p<0.05). In terms of meat quality, the HC resulted in two times greater fat content in both muscles examined compared to intact males. More importantly, the shear force values did not differ between HC and CC groups for L. lumborum muscles (p>0.05). The meat from HC animals exhibited higher amount of free amino acids associated with sweetness (p<0.05). Furthermore, the castration method only exhibited a negligible effect on metabolites and volatile aroma compounds in the cooked meat. CONCLUSION: Half-castration emerged as an alternative practice to be used for increasing the yield and tenderness of male cattle meat.

Effects of Dietary Protein Concentration on Lipid Metabolism Gene Expression and Fatty Acid Composition in 18-23-Month-Old Hanwoo Steers.

The present study evaluated the influence of dietary protein level on growth performance, fatty acid composition, and the expression of lipid metabolic genes in intramuscular adipose tissues from 18- to 23-month-old Hanwoo steers, representing the switching point of the lean-to-fat ratio. Forty steers with an initial live weight of 486 ± 37 kg were assigned to one of two treatment groups fed either a concentrate diet with 14.5% CP and or with 17% CP for 6 months. Biopsy samples of intramuscular tissue were collected to analyze the fatty acid composition and gene expression at 23 months of age. Throughout the entire experimental period, all steers were restrained twice daily to allow individual feeding. Growth performance, blood metabolites, and carcass traits, according to ultrasonic measurements, were not affected by the experimental diets. The high-protein diet significantly increased the expression of intramuscular PPARα (p < 0.1) and LPL (p < 0.05) but did not affect genes involved in fatty acid uptake (CD36 and FABP4) nor lipogenesis (ACACA, FASN, and SCD). In addition, it downregulated intramuscular VLCAD (p < 0.01) related to lipogenesis but also GPAT1 (p = 0.001), DGAT2 (p = 0.016), and SNAP23 (p = 0.057), which are involved in fatty acid esterification and adipocyte size. Hanwoo steers fed a high-protein diet at 18-23 months of age resulted in a relatively lower lipid turnover rate than steers fed a low-protein diet, which could be responsible for shortening the feeding period.

Effect of Hemi-Castration on the Productivity, Histological Characteristics, and Economic Efficacy of Korean Beef Cattle.

We evaluated the growth performance, serum testosterone, carcass traits, histological characteristics, and economic efficacy of castrated and hemi-castrated Korean beef cattle. Thirty-two Hanwoo calves (Initial body weight: 148.4 ± 19.8 kg) were randomly assigned into the castrated Hanwoo (CH) and hemi-castrated Hanwoo (HH) group. The experiment lasted 18 months; the animals were all slaughtered on the same day. Final body weight and average daily gain (ADG) tended to increase in the HH group compared to the CH group. Testosterone concentration was higher in HH group (5.27-14.27 ng/dL) than in the CH group (0.47-0.70 ng/dL) during the whole experimental period after castration (p < 0.05). Rib eye area was 17.08 cm2 wider in HH group than in CH group, but marbling score was improved by 3.33 in CH group compared to HH group (p < 0.01). Deposition area of adipocytes in Longissimus dorsi were higher in CH group than in HH group (p < 0.001). Net income per head was 1760 US dollar higher in the CH group than in the HH group (p < 0.04). Thus, our findings suggest that hemi-castration had positive effects on the increase in ADG and meat yield traits, with negative effects on marbling and profitability.

Nutritional value and in situ degradability of oak wood roughage and its feeding effects on growth performance and behavior of Hanwoo steers during the early fattening period.

OBJECTIVE: This study was conducted to evaluate changes in nutritional value and in situ dry matter (DM) degradability of oak and pine wood before and after steam-digestion process (60 min/160°C/6 atm) and feeding effect of the oak roughage on performance and behavior of Hanwoo steers. METHODS: Chemical composition and tannin concentration were analyzed for oak and pine trees before and after the pretreatment. In situ DM and effective degradability of these samples were assessed using a nylon bag method. In vivo trial was performed to estimate animal performance and behavior, using steers fed total mixed ration (TMR) diets containing 0% (control), 25% (OR-25), and 50% (OR-50) of the oak roughage. Eighteen steers were allocated into nine pens (2 steers/pen, 3 pens/treatment) for 52 days according to body weight (BW) and age. RESULTS: By the steam-digestion treatment, the neutral detergent-insoluble fiber was decreased from 86.5% to 71.5% for oak and from 92.4% to 80.5% for pine, thereby increasing non-fiber carbohydrate. In situ DM degradability of treated oak reached 38% at 72 h, whereas that of untreated oak was only 11.9%. The 0 h degradability of the treated pine increased from 5.9% to 12.1%, but the degradability was unchanged thereafter. Animal performance including BW, average daily gain, DM intake, and feed conversion ratio was not different among control and oak treatments. No differences were detected in animal behavior such as lying, standing, rumination, drinking, and eating, except walking. Walking was higher in control than oak treatments with numerically higher eating and lower lying times, probably due to bulkier characteristics of rice straw in the diet. CONCLUSION: This study demonstrates that the oak roughage can be substituted for 50% of total forage or 100% of rice straw in TMR diets at early fattening stage of Hanwoo steers.

Characteristics of sawdust, wood shavings and their mixture from different pine species as bedding materials for Hanwoo cattle.

OBJECTIVE: This study was conducted to evaluate the physicochemical properties and changes in moisture concentrations of bedding materials under the conditions of rearing Korean Hanwoo cows. METHODS: Two experiments were conducted to investigate the physicochemical characteristics (Exp. I) and usefulness as beddings for rearing cattle (Exp. II) by the type of beddings such as sawdust (SD), wood shavings (WS) and sawdust+wood shavings (S+W; 1:1 in volume), and the species of pine trees from different countries of origins (China, Pinus armandii, AR; Vietnam, Pinus kesiya, KE; USA, Pinus rigida, RI). RESULTS: In Exp. I, SD-AR showed the largest proportion (78.3%) of fine particles (250 µm+ below 250 µm) and the highest bulk density (208 kg/m3) among treatments (p<0.05). The water absorption capacity at 24 h of both S+W-RI (713%) and -KE (701%) was the highest among treatments (p<0.05) and higher than those of SD or WS alone within each species of pine tree (p<0.05). Moisture evaporation rates (%) at 12 h were ranged from 52.3 to 60.8 for SD, 69.9 to 74.4 for WS, and 72.3 to 73.5 for S+W. Total amounts (mg/m2) of ammonia emissions were the lowest (p<0.05) in KE species among the pine species within each type of bedding material, having higher ability of ammonia absorption. In Exp II, KE species in both side A and B had lower moisture concentrations (%) than other species. Regardless of types of beddings except SD-AR, moisture concentrations of beddings within a pen were higher (p<0.01) at side A than B. CONCLUSION: The KE species has better physical characteristics than other beddings and more useful for rearing Hanwoo cattle than other beddings, probably caused by the differences in the method and degree of wood processing rather than the species.

Effects of supplementing Barodon, Bacillus subtilis, and Ampbio on growth performance, biochemical metabolites, and hormone levels in Korean native heifers.

An experiment was conducted to evaluate the effects of supplementing feed additives of Barodon®, effective microorganism® (Bacillus (B.) subtilis), and Ampbio® on the growth performance, blood metabolites, stress, and reproductive hormone levels of Korean native heifers. A total of 48 Korean native heifers were assigned to four groups with 6 heifers in each group. The groups were control, Barodon (0.2%), beneficial microorganism (1%), and Ampbio (1%). Animals in all groups were fed a basal diet composed of selected feed additives and water ad libitum for 99 days. Results showed that there are significant changes in body weight and daily gain in the Ampbio-supplemented group as compared with the control and other feed additives groups (p < 0.05). The increased level of feed intake (7.30 ± 0.03 kg) and feed requirements (10.81 ± 0.52 kg) was observed in the Ampbio-fed group followed by the effective microorganism (EM), Barodon, and control groups. There were no significant changes in albumin, glucose, glutamic oxaloacetic transaminase (SGOT), serum pyruvic transaminase (SGPT), and total protein level, but the decreased levels of total cholesterol and triglycerides and the increased level of blood urea nitrogen were noted in the Ampbio-fed group as compared with the control and other feed additive groups. The reduced level of cortisol (p < 0.05) and elevated levels of progesterone and estradiol (p > 0.05) were noted in the Ampbio-fed group as compared to the other feed additive groups. It is therefore concluded that incorporation of Barodon, EM (B. subtilis), and Ampbio in the recommended diet improved the growth and health performance of Korean native heifers.

Production of chitinase from Escherichia fergusonii, chitosanase from Chryseobacterium indologenes, Comamonas koreensis and its application in N-acetylglucosamine production.

The important platform polysaccharide N-acetylglucosamine (GlcNAc) has great potential to be used in the fields of food, cosmetics, agricultural, pharmaceutical, medicine and biotechnology. This GlcNAc is being produced by traditional methods of environment-unfriendly chemical digestion with strong acids. Therefore, researchers have been paying more attention to enzymatic hydrolysis process for the production of GlcNAc. Hence, in this study, we isolated novel chitinase (Escherichia fergusonii) and chitosanase (Chryseobacterium indologenes, Comamonas koreensis) producing strains from Korean native calves feces, and developed the potential of an eco-friendly microbial progression for GlcNAc production from swollen chitin and chitosan by enzymatic degradation. Maximum chitinase (7.24±0.07U/ml) and chitosanase (8.42±0.09, 8.51±0.25U/ml) enzyme activity were reached in submerged fermentation at an optimal pH of 7.0 and 30°C. In this study, sucrose, yeast extract, (NH4)2SO4, and NaCl were found to be the potential enhancers of exo-chitinase activity and glucose, corn flour, yeast extract, soybean flour, (NH4)2SO4, NH4Cl and K2HPO4 were found to be the potential activator for exo-chitosanase activity. Optimum concentrations of the carbon sources for enhanced chitinase activity were 9.91, 3.21, 9.86, 1.66U/ml and chitosanase activity were 1.63, 1.13, 2.28, 3.71, 9.02, 4.93, and 2.14U/ml. These enzymes efficiently hydrolyzed swollen chitin and chitosan to N-acetylglucosamine were characterized by thin layer chromatography and were further confirmed by high-pressure liquid chromatography. From a commercial perspective, we isolated, optimized and characterized exochitinase from Escherichia fergusonii (HANDI 110) and chitosanase from Chryseobacterium indologenes (HANYOO), and Comamonas koreensis (HANWOO) for the large-scale production of GlcNAc facilitating its potential use in industrial applications.

Characteristics of Wet Distillers Grains on In vitro Ruminal Fermentation and Its Effects on Performance and Carcass Characteristics of Finishing Hanwoo Steers.

Two experiments were conducted to determine the nutrient composition, in vitro ruminal ammonia concentrations and pH of wet distillers grains (WDG, produced from tapioca 70% and rice 30%) and to evaluate dietary effects of fermented total mixed ration (TMR) using WDG on the performance, blood metabolites and carcass characteristics of Hanwoo steers from mid fattening to slaughter. In Exp. I, average dry matter (DM), crude protein, ether extract, crude fiber, ash, neutral detergent fiber, acid detergent fiber, and nitrogen free extract of seven WDG samples from an ethanol plant with different sampling dates were 19.9%, 24.8%, 3.8%, 21.8%, 8.87%, 60.3%, 34.5%, and 40.7% (DM basis), respectively. For in vitro ammonia concentrations and pH, each sample was assigned to 7 incubation times (0, 4, 8, 12, 24, 48, and 72 h). Linear increase was observed between 12 and 48 h for ammonia concentrations, but final ammonia concentrations (72 h) were not significantly different among WDG samples and fermentation patterns of WDG samples showed similar tendency. In vitro pH varied among treatments from 0 to 24 h, but were not different statistically after 48 h. In Exp. II, 45 Hanwoo steers of 23 months (641±123 kg) from mid fattening period to slaughter (248 days) were randomly divided into three groups of 15 pens each (five repetitions/each treatment) and assigned to one of three dietary treatments; i) Control (TMR), ii) WDG 15 (TMR containing 15% of WDG, as fed basis) and iii) WDG 28 (TMR containing 28% of WDG, as fed basis). The body weight (BW), ADG, and feed conversion ratio (FCR) of control and WDG 15 and 28 during 248 days were 760.8, 740.1, and 765.5 kg, and 0.50, 0.50, and 0.52 kg/d, and 18.6, 17.6, and 17.1, respectively. The dry matter intake (DMI) (kg/d) of control (9.11) was higher (p<0.05) than WDG treatments (WDG 15%, 8.57; 28%, 8.70). Nevertheless, DMI did not affect BW, ADG, and FCR of Hanwoo finishing steers. Blood metabolites were in normal ranges and were not different among treatments except the albumin concentration. In carcass characteristics, WDG 15 (30%) showed higher frequency of A-carcass yield grade than WDG 28 (15%) and control (7%), and WDG 28 (61%) showed higher frequency of 1(++) and 1(+)-carcass quality grade than WDG 15 (40%) and control (60%). In conclusion, using WDG up to 28% in TMR did not show any negative effect on the performance and blood metabolites, and improved carcass quality of Hanwoo steers. Therefore, WDG can be a useful feed ingredient for Hanwoo steers in mid-fattening period to slaughter.

Characteristics of Rice Hulls, Sawdust, Wood Shavings and Mixture of Sawdust and Wood Shavings, and Their Usefulness According to the Pen Location for Hanwoo Cattle.

In this study, two experiments were conducted to investigate the physicochemical characteristics (Exp. I) of bedding materials such as rice hulls (RH), sawdust (SD), wood shavings (WS) and sawdust+wood shavings (S+W; 1:1 in volume), and utilization of these beddings except RH (Exp. II) for rearing beef cattle. In Exp. I, the distribution of particle size (%) with 250 µm and below 250 µm was greater (p<0.05) in SD (30.4) than RH (4.4), WS (18.8) and S+W (20.1). Bulk density (kg/m(3)) of bedding materials was directly proportional to the percentage of 250 µm and below 250 µm particles, 178, 46, 112, and 88 for SD, WD, S+W and RH, respectively. Water absorption rate (%) after submersion in water for 24 h was higher (p<0.05) in WS (540.2) compared to SD (270.2), S+W (368.2). The S+W had an intermediate value of the absorption rate between SD and WS, but had an outstanding durability of water absorption capacity. Moisture evaporation rate (%) for 12 h was higher (p<0.05) in WS (75.4) than SD (70.5), S+W (72.2) and RH (57.8). Average ammonia emission (mg/m(2)/h) for 36 h was higher (p<0.05) in RH (3.15) than SD (1.70), WS (1.63), and S+W (1.73). In Exp. II, thirty six Hanwoo cows were allocated in 9 pens with one side on feed bunk side (Side A) and another side equipped with water supply (Side B) for 3 weeks with duplicated periods. Average moisture concentrations (%) of beddings were higher (p<0.05) in WS (side A, 65.7; side B, 57.9) than SD (side A, 62.5; side B, 52.2) and S+W (side A, 61.6; side B, 50.7). Regardless of types of beddings, moisture concentrations (%) of beddings within a pen were lower (p<0.05) at side B than A, implying longer period of utilization. These results suggest that using S+W would be a better choice than SD or WS alone, considering physicochemical characteristics and economics, and RH is not a suitable material as a bedding for beef cattle.

Characteristics of Sawdust and Cocopeat Beddings, and Their Usefulness According to the Fan and Pen Location for Rearing Hanwoo Cattle.

This study was designed to examine the characteristics of sawdust and cocopeat bedding materials, including physicochemical properties (Exp. I) and on-farm trial (Exp. II). In Exp. I, the proportion of particle size was in the order of sawdust> cocopeat India>cocopeat Vietnam (p<0.05), and cocopeat contained higher proportion of small particles (250 µm+below 250 µm) than sawdust, causing a dust production problem. Bulk density was cocopeat India>cocopeat Vietnam>sawdust (p<0.05), thus cocopeat treatments showed 4.4 times higher bedding cost than sawdust. The water absorption rates were 702.0% in cocopeat India, 678.3% in cocopeat Vietnam, and 444.0% in sawdust, showing cocopeat had approximately 1.5 times higher water absorption rate than sawdust. Moisture evaporation rates after 12 h of air blowing (2.00 m/s) were higher (p<0.05) in cocopeat Vietnam (80.4%) than sawdust (71.2%) and cocopeat India (72.8%). In vitro ammonia emissions were higher (p<0.05) in sawdust (2.71 mg/m(2)/h) than cocopeat India (1.59 mg/m(2)/h) and Vietnam (1.22 mg/m(2)/h), and total ammonia emissions were higher (p<0.05) in sawdust (37.02 mg/m(2)) than cocopeat India (22.51 mg/m(2)) and Vietnam (13.60 mg/m(2)). In Exp. II, an on-farm trial was conducted with 48 Hanwoo cattle in 16 pens using the same bedding materials as in Exp. I, with fan (blowing 2.00 m/s) and no fan treatments, and feed bunk side (FB) and water supply side (WS) within a pen (4.5 m, width×9.0 m, length). Beddings were replaced with fresh bedding materials when moisture concentrations were over 65%. No interactions among treatments were detected for moisture concentration and increment rates, and ammonia concentrations, but a significant effect was observed (p<0.01) for each of the treatments. Both concentrations and increment rate of moisture were higher (p<0.01) in the beddings without fan than with fan. Moisture concentrations and increment rate within a pen were also higher (p<0.01) in FB than WS. Thus, the whole no-fan-FB and sawdust-fan-FB were replaced with fresh bedding material between 4 to 5 experimental weeks. The ammonia concentrations and pH of beddings were not significantly different among treatments. Therefore, using cocopeat bedding with a blowing fan can extend twice the bedding utilization period, and WS within a pen showed twice the bedding-life compared to FB. Despite the outstanding characteristics of cocopeat compared with sawdust, using cocopeat as an alternative for sawdust bedding is not recommended for cattle management, considering it has 4.4 times higher bedding cost and a dust production problem.

Effects of catechins and wheat bran on the beef color in the late fattening period of hanwoo steers.

This study was conducted to evaluate the effects of dietary supplementation of catechins and wheat bran on growth performance, carcass characteristics and meat color using forty-eight Hanwoo steers. Each steer was randomly assigned to one of four treatments. Treatments were as follows: control, catechins, wheat bran, and catechins+wheat bran (CW). At the end of the feeding trial, blood samples were collected for analysis of hemoglobin and iron concentration, and then steers were slaughtered at a commercial abattoir. Catechins, wheat bran, and CW had no effect on growth performance and carcass characteristics. Percentage of myoglobin in M. longissimus dorsi was not affected by treatments. Percentage of oxymyoglobin was increased (p<0.05) by CW and maintained at the highest level (p<0.05) for CW during meat display time up to 24 h. Percentage of metmyoglobin was the lowest (p<0.05) for CW between 5 and 24 h during display time. Although blood iron concentration was not affected by treatments, total concentration of muscle iron was the lowest (p<0.05) for CW compared with that of other treatments. Therefore, the results of the present study suggest that CW may provide good protection against oxidation of myoglobin, and might be an effective dietary supplement for improving meat color in the late fattening period of Hanwoo steers.